Minica

KJ-0343-0

Submitted by administrator on Wed, 03/04/2015 - 00:58

The oil seal of the power steering gearbox may have been damaged when the rack bar in the gearbox was installed. If this problem is left unattended, oil may leak, and in the worst case, the steering would become heavier.

RJ-1248-0

Submitted by administrator on Wed, 03/04/2015 - 00:54

On certain vehicles with DOHC, there is a flaw in the camshaft for exhaust valve (on the boss for lubricant), caused during manufacturing. If this problem is left unattended, in the worst case, the camshaft for exhaust valve may break, making opening/closing of the valve impossible, and in which case the engine stops and will not restart.

RJ-1120-0

Submitted by administrator on Wed, 03/04/2015 - 00:53

On certain vehicles with manual transmission, a clutch pedal operation may cause interference between the top part of the clutch pedal and the electric wires, because the wires are not properly secured. At worst, this may cause a short circuit and a blown fuse, and result in no illumination of the lights such as headlights or overheating.

RJ-1095-0

Submitted by administrator on Wed, 03/04/2015 - 00:53

The coating life of the orange colour coats for the turn signal bulbs is not long enough due to the material. If left unfixed, the orange coats may exfoliate, and the lighting colour may become white.

RJ-0856-0

Submitted by administrator on Wed, 03/04/2015 - 00:53

The top of the battery may get wet with water such as rainwater because the battery is improperly positioned, and the water can get into the inside of the battery from the vent plugs. As a result, the battery liquid level increases, and the overflowed liquid may spatter on the brake pipe for the left front wheel. At worst, the brake pipe corrodes, causing the brake fluid to leak, and this could result in reduced brake efficiency.